What causes a diesel engine hard to start?

It’s the middle of summer and your diesel engine is having trouble getting started. The problems that can occur due to the cold weather are well-known and fairly common, such as using summer-grade fuel in winter, a bad glow plug system, slow cranking, or thick, cold oil.

What causes hard starting engine?

Fouled plugs are one of the most common reasons for a hard starting engine. … This can lead to prolonged cranking before the engine will start. Clogged Fuel Filter: A fuel filter that is clogged can make a vehicle very difficult to start. The fuel filter screens out contaminants and can become clogged over time.

How do you start a stubborn diesel engine?

Set the choke



You can open up this automatic choke by pressing the gas pedal all the way down and then raising it about halfway up before starting the engine. You might also need to pump the gas pedal quickly 5-6 times, drawing fuel into the carburetor on especially old pickups.

How can I improve my diesel cold start?

With this in mind, here are six tips for starting a diesel in cold weather and maintaining your equipment over time.

  1. Do Not Underestimate Warm-Up Time. …
  2. Consider Heating Options. …
  3. Keep Your Diesel Exhaust Fluid Thawed. …
  4. Address Frozen Fuel. …
  5. Keep Your Engine in a Warm Area. …
  6. Make Sure Your Fuel Tank is Full.
IT IS INTERESTING:  Best answer: How much does an engine block cost?

How do you fix a hard start engine?

How to Troubleshoot a Car That is Hard to Start

  1. Step 1: Insert your key. …
  2. Step 2: Starter pushes the flywheel or flexplate. …
  3. Step 3: The engine turns over. …
  4. Step 1: Start the car in Park. …
  5. Step 2: Check the battery. …
  6. Step 3: Check the starter. …
  7. Step 4: Check the spark. …
  8. Step 5: Check the fuel.

What are the signs of a bad ignition coil?

Ignition Coil Problems, Symptoms and Solutions

  • Engine misfires.
  • Rough idle.
  • A decrease in car power, especially in acceleration.
  • Poor fuel economy.
  • Difficulty starting the engine.
  • Check engine light is on.
  • Exhaust backfiring.
  • Increased hydrocarbon emissions.

Are cold starts bad for diesels?

Myth #2: Diesel engines won’t start in the winter.



​“Modern diesel engines start in cold weather with very little effort.” … Diesel isn’t so volatile; if you tossed that match into a pool of diesel, it would go out.” Glow plugs and other remedies, however, effectively vaporize diesel to prepare it for combustion.

Can a diesel start without glow plugs?

9 Answers. Glow plug is merely an aid for starting the engine. There are many designs still produced today without any glow plugs (eg military diesels run without any electricity), and even many modern diesel engines can be started if glow plugs fail (unless onboard computer prevents that).

Is it bad to not plug in a diesel?

A general rule of thumb is to plug in your engine block heater when the weather reaches -15° C or lower, just to be safe. If you drive a diesel vehicle, you may need to plug in the engine block heater before temperatures drop that low. … Diesel engines can be harder to start in even slightly cold weather.

IT IS INTERESTING:  Can you void a car warranty?

How cold is too cold for diesel?

Diesel fuel gelling has the potential to occur when temperatures drop below 32 degrees Fahrenheit, although the exact temperature it happens at will vary from fuel batch to fuel batch.

Should you press the accelerator when starting a diesel car?

Yes, it is certainly useless in any modern engine, gasoline or diesel. They all use computer control of fuel and mixture, so doing anything with the accelerator before the engine starts does nothing to the engine.

Blog about car repair